炼油技术与工程 ›› 2021, Vol. 51 ›› Issue (7): 14-17.

• 加工工艺 • 上一篇    下一篇

中低温煤焦油悬浮床加氢馏分制取特种溶剂油工艺研究*

陈新宇, 刘丹禾, 刘金龙, 韩海波, 李鹏程   

  1. 中石化炼化工程(集团)股份有限公司洛阳技术研发中心,河南省洛阳市 471003
  • 收稿日期:2021-01-14 修回日期:2021-04-12 出版日期:2021-07-15 发布日期:2021-11-16
  • 作者简介:陈新宇,高级工程师,博士,2011年毕业于天津大学化学工艺专业,研究方向为馏分油加氢技术。联系电话:0379-64868808,E-mail:chenxinyu.segr@sinopec.com。
  • 基金资助:
    *国家重点研究发展计划(2017YFB0602803-3)。

Study on preparation of special solvent oil by middle/low-temperature coal tar suspending-bed hydrocraking distillate oil

Chen Xinyu, Liu Danhe, Liu Jinlong, Han Haibo, Li Pengcheng   

  1. SEG Luoyang R & D Center of Technology, Luoyang, Henan 471003
  • Received:2021-01-14 Revised:2021-04-12 Online:2021-07-15 Published:2021-11-16

PDF

摘要： 以中低温煤焦油非均相悬浮床加氢工艺的馏分油为原料,在100 mL固定床反应器上加氢精制制取环保特种溶剂油。考察了反应温度、反应压力、氢油比和空速以及不同馏分段和工艺方案对产品性质的影响。结果表明,选用300 ℃以下馏分油为原料,采用两段加氢工艺更适合煤基溶剂油原料的加氢精制。反应器1装填针对煤基溶剂油原料的加氢精制催化剂LP-D,反应器2采用石油基溶剂油加氢精制工业剂LK-1。反应器1反应温度 320 ℃,氢油比600,液时空速0.50 h-1,压力16 MPa;反应器2反应温度360 ℃,氢油比600,液时空速0.33 h-1,压力16 MPa。经两段加氢精制后生成油的硫、氮和芳烃质量分数分别降至0.8,0.5 μg/g和0.08%,该工艺方案可满足环保特种溶剂油的生产要求。

关键词: 中低温煤焦油, 悬浮床加氢馏分, 特种溶剂油, 两段加氢工艺

Abstract: Special solvent oil was prepared from the middle and low temperature coal tar suspension bed hydrogenation fraction via hydrofining route on a 100 mL fixed bed reactor. The effects of temperature, pressure, hydrogen-oil ratio, LHSV ,different fractions and process schemes on product properties were studied. The results showed that the two-stage hydrogenation process was more suitable for the hydrogenation of coal based solvent oil with distillates below 300 ℃ as raw materials. The catalyst LP-D for coal-based solvent oil was filled in the first reactor, and the oil-based solvent oil hydrogenation industrial agent LK-1 was used in the second reator. The first rector's temperature was 320 ℃, hydrogen-oil ratio was 600, LHSV was 0.50 h-1, and pressure was 16 MPa. The second reactor's temperature was 360 ℃, hydrogen-oil ratio was 600, space velocity was 0.33 h-1, pressure was 16 MPa. The mass fractions of sulfur, nitrogen and aromatics in the generated oil were reduced to 0.8, 0.5 μg/g and 0.08% respectively after being hydrotreated. The process can meet the production requirements of environmental protection special solvent oil.

Key words: medium and low temperature coal tar, suspension bed hydrogenation fraction, special solvent oil, two-stage hydrogenation process